Evaluation of multicomponent recombinant vaccines against Actinobacillus pleuropneumoniae in mice

Background Porcine contagious pleuropneumonia (PCP) is a highly contagious disease that is caused by Actinobacillus pleuropneumoniae (APP) and characterized by severe fibrinous necrotizing hemorrhagic pleuropneumonia, which is a severe threat to the swine industry. In addition to APP RTX-toxins I (ApxI), APP RTX-toxin II (ApxII), APP RTX-toxin III (ApxIII) and Outer membrane protein (OMP), there may be other useful antigens that can contribute to protection. In the development of an efficacious vaccine against APP, the immunogenicities of multicomponent recombinant subunit vaccines were evaluated. Methods Six major virulent factor genes of APP, i.e., apxI, apxII, apxIII, APP RTX-toxins IV (apxIV), omp and type 4 fimbrial structural (apfa) were expressed. BALB/c mice were immunized with recombinant ApxI ( rApxI), recombinant ApxII (rApxII), recombinant ApxIII (rApxIII) and recombinant OMP (rOMP) (Group I); rApxI, rApxII, rApxIII, recombinant ApxIV (rApxIV), recombinant Apfa (rApfa) and rOMP (Group II); APP serotype 1 (APP1) inactivated vaccine (Group III); or phosphate-buffered saline (PBS) (Control group), respectively. After the first immunization, mice were subjected to two booster immunizations at 2-week intervals, followed by challenge with APP1 Shope 4074 and APP2 S1536. Results The efficacy of the multicomponent recombinant subunit vaccines was evaluated on the basis of antibody titers, survival rates, lung lesions and indirect immunofluorescence (IIF) detection of APP. The antibody level of Group I was significantly higher than those of the other three groups (P < 0.05). The survival rate of Group I was higher than that of Groups II and III (P < 0.05) and the control (P < 0.01). Compared with the other three groups, the lungs of Group I did not exhibit obvious hemorrhage or necrosis, and only showed weak and scattered fluorescent dots by IIF detection. Conclusion The result indicates that the multicomponent recombinant subunit vaccine composed of rApxI, rApxII, rApxIII and rOMP can provide effective cross-protection against homologous and heterologous APP challenge.


Background
Porcine contagious pleuropneumonia (PCP) is a highly contagious disease that is caused by Actinobacillus pleuropneumoniae (APP) and characterized by severe fibrinous necrotizing hemorrhagic pleuropneumonia [1], which is a severe threat to the swine industry.
At present, an inactivated whole cell vaccine derived from APP is used for PCP prevention in many countries [2,3]. However, the protection provided by the inactivated vaccine is not sufficient [4,5], for the reason that the inactivated vaccine rarely contains exotoxins excreted to the medium by the bacteria during growth [6][7][8]. In addition, some protein components may be damaged or lost during the inactivation process. Several studies have shown that effective protection can be provided by combined subunit vaccines composed of virulence factors of APP [9,10], such as transferrin-binding protein, lipoprotein [11], capsular polysaccharide [CPS] or lipopolysaccharide [LPS] [12]. Combined subunit vaccines, such as the multicomponent vaccine composed of APP RTX-toxins I (ApxI), APP RTX-toxin II (ApxII), APP RTX-toxin III (ApxIII) and Outer membrane protein (OMP), can provide higher protective efficacy against challenge with 12 serotypes of APP [13,14], which demonstrates that the development of multicomponent subunit vaccines should be pursued further.
In addition to ApxI, ApxII, ApxIII and OMP, there may be other useful antigens that can contribute to protection. As an important virulent factor, the pilus has excellent immunogenicity among many Gram-negative bacteria [15][16][17]. The enterotoxigenic CS4 pilus of Escherichia coli (E. coli) [18] and the toxin-coregulated pilus (TCP) of Vibrio cholerae [19] have been chosen as candidate antigens for subunit vaccines. The type 4 fimbrial structural gene (apfA) of APP was shown to be present and highly preserved in different serotypes of APP [20,21], which suggests that the pilus of APP may have potential to be a component for vaccine preparation.
APP RTX-toxin IV (ApxIV) toxin is another potentially valuable antigen that has been identified within recent years as an APP toxin. The ApxIV toxin was shown to be the only toxin that can be produced by all serotypes of APP and is only expressed in vivo during infection. Moreover, ApxIV toxin can stimulate a high level of antibody [22]. These findings indicate that ApxIV toxin may be responsible for cross-protection in pigs that have recovered from natural infection and are resistant to reinfection with any other serotype of APP.
In this study, we cloned and expressed ApxI, ApxII, ApxIII toxins, OMP as well as the Apfa and ApxIV toxin of APP. On the basis of these recombinant antigens, different multi-component recombinant vaccines were made, and the efficacy of these vaccines was evaluated in order to determine whether the Apfa toxin can contribute to the protective immunity of a recombinant subunit vaccine.

Bacterial strains, growth conditions, vectors and sera
The APP serotype 1 reference strain Shope 4074, APP serotype 2 reference strain S1536 and E. coli BL21 were obtained from the Chinese Institute of Veterinary Drug Control (IVDC); the prokaryotic expression vector pGEX-6P-1 was purchased from Invitrogen (Carlsbad, CA, USA). Rabbit antisera were produced by immunization of rabbits with inactivated APP1 and APP2; the immunization was performed by multipoint subcutaneous injections, and the immunization schedule comprised three immunizations at 2-week intervals. Ten days after the third immunization, blood was collected and the serum was separated and stored in our laboratory. The APP was grown in beef heart infusion broth or agar supplemented with 10% horse serum and 100 μg/ml Nicotinamide Adenine Dinucleotide (NAD), and the E. coli BL21 strain was grown in Luria-Bertani (LB) broth or agar containing 50 μg/ml ampicillin.

Mice
Male BALB/c mice (n = 80), aged 6 weeks, were purchased from Harbin Medical University. Animal experiments were performed in accordance with the guidelines of Chinese Council on Animal Care. The research protocol was approved by Harbin Veterinary Research Institute Committees on Biosafety.

Expression and purification of recombinant proteins
The genes apxIA, apxIVA, apfa and omp were amplified from the APP1 Shope 4074 genome; apxIIA and apxIIIA were amplified from the APP2 S1536 genome by PCR according to the reaction conditions shown in Table 1.

Immunization of mice
Male BALB/c mice (n = 80) were randomly allocated in equal numbers to each of three vaccination treatments and a PBS control, twenty mice were used in each group. The mice were immunized using 0.2 ml for each group [7] ( Table 2). The immunization was performed by multipoint subcutaneous injection. The first, second and third immunizations were performed at 7, 9 and 11 weeks of age, respectively. One week after the first immunization, blood was harvested each week from the tail vein (0.1 ml/animal) for the serum antibody assay.

Antibody analysis
Specific antibodies were measured by indirect ELISA (iELISA) [24]. Native ApxI, ApxII, ApxIII, Apfa and OMP were extracted as described previously [25][26][27]. Because ApxIV is expressed only in vivo during infection, it could not been extracted from the culture of APP. The crude extracts were recovered and purified by 12% SDS-PAGE. The ELISA plates (Costar, eBioscience, San Diego, CA, USA) were coated with 10 μg/ml ApxI, ApxII, ApxIII, Apfa or OMP (50 μl/well). Sera of immunized mice were diluted (1:100, 50 μl/well) with PBST (PBS with 0.1% Tween 20) as the first antibody, and HRP-conjugated goat anti-mouse IgG (Sigma Aldrich) (1:10 000 dilution, 50 μl/well) was used as the second antibody. Washing was carried out three times with PBST between each step. All reaction mixtures were set up in triplicate, and the average values were used for recording and calculation. The results were read on a Dynatech MR 7000 ELISA reader (Bio-Rad mode l680). The OD 490 was read to record the ELISA score.

Data analysis
The data were analyzed using the general linear model (GLM) procedure of Statistical Analysis System (SAS, 1997. Base SAS Software Reference Card. Version 6.12, Cary, NC, SAS Institute Inc., USA, p.211-253).

Challenge after immunization
One week after the third immunization, the surviving animals in each group were subdivided again into two equal subgroups within each group. The mice in one subgroup of each group were challenged intranasally with 5 × 10 9 colony forming units (CFU) of APP1, and the mice in the other subgroups were challenged with APP2 (5 × 10 10 CFU). The LD 50 was calculated as described previously [28]. Animals were sacrificed on the sixth day after challenge.

Histopathology and indirect immunofluorescence (IIF) test
Lung samples were separated into two parts. One part was fixed by formalin, followed by hematoxylin and eosin (HE) staining for the observation of histological changes. Briefly, the lung of each mouse was fixed in 10% formalin, embedded in paraffin and cut into 5-6 μm sections. All sections were heated at 56°C for 25 min, deparaffinized in xylene, rehydrated with graded alcohols, and then stained with HE for histological observation using light microscopy (Olympus, Tokyo, Japan). The other part of each lung was cut into sections using a freezing microtome for the detection of the distribution of APP in lung tissue using the IIF method [29]. Briefly, lung samples were embedded in a Tissue-Tek OCT compound (Miles, Inc., Elkhart, IN) and frozen in liquid nitrogen. Frozen sections (4 μm) were mounted on slides coated with poly-L-lysine and fixed in pre-cooled acetone for 5 min. Sections were then covered with 20 μl rabbit antiserum against APP1 or APP2 (1:50 dilution) and incubated at 37°C for 1 h. After washing in PBS, the sections were covered with 20 μl FITC-labeled goat anti-rabbit IgG (Sigma-Aldrich) (1:100 dilution) and incubated at 37°C for 1 h. Immunofluorescence images were observed with an Olympus A×70 fluorescence microscope (Olympus, Tokyo, Japan).

Detection of serum antibodies
The serum antibodies to rApxI, rApxII, rApxIII, rOMP and rApfa in various groups were examined and the findings are summarized in Fig. 1.
Two weeks after the second immunization, antibodies against rApxI and rOMP in the mice in group I were significantly higher (P < 0.01) than those in the other three groups. Antibodies against rApxII and rApxIII were also higher in the mice in Group I than in the other three groups (P < 0.05). All antibody levels of the mice in Group I (against rApxI, rApxII, rApxIII and rOMP) were significantly higher (P < 0.01) than those in the other three groups one week after the third immunization (Table 3).
Antibodies against rApxI, rApxII, rApxIII and rApfa were significantly higher in the mice in Group II than in those in Group III and in the control group 2 weeks after the second immunization (P < 0.05). The rOMP antibody level of the mice in Group II was the same as that of Group III and these levels were significantly higher than that in the control group (P < 0.01). Antibody levels against rApxI, rApxII, rApxIII and rApfa in the mice in Group III were slightly higher than those in the control group but were not significantly different (P > 0.05).

Mortality and histopathology
The challenge doses of APP1 Shope 4074 and APP2 S1536 were 5×10 9 cfu and 5×10 10 cfu respectively. Within 24 h after challenge with APP1 and 36 h after challenge with APP2, all control mice died. The survival rate of Group I was higher than that of Groups II and III (P <0.05) and the control group (P <0.01). The results are summarized in Table 2. Bleeding from the mouth and nose was apparent in all dead mice. The lungs of the dead mice challenged with APP1 (Fig. 2a) and APP2 (Fig. 2e) showed severe lung lesions. Congestion, hemorrhage, necrosis and parenchyma consolidation were observed in the lungs, and extensive serous and fibrinous exudates had accumulated together with a substantial infiltration of inflammatory cells. All the other surviving mice were euthanized 5 days post challenge with APP1 or APP2. The mice in Group I challenged with APP1 (Fig. 2b) or APP2 (Fig. 2f) had less severe lung lesions than those in Groups II and III (Fig. 2c, 2d, 2g, 2h), with less hemorrhage and necrosis. The mice in Groups II and III showed moderate lung lesions, with pulmonary congestion, hemorrhage, serous and fibrinous exudation in some areas, inflammatory cell infiltration, as well as partial rupture of alveolar structures, and lysis.

IIF detection
The results of IIF detection are shown in Table 4. In Group I, there were only weak and scattered fluorescent dots observed in individual alveoli and alveolar septa of the surviving mice. In contrast, in those in groups and Group III, the fluorescence dots were more dense and stronger than in Group I. However, the strongest fluorescence was observed in most alveoli and alveolar septa of the dead mice in the control group as well as those in Groups I-III.

Discussion
This study showed that a recombinant subunit vaccine consisting of rApxI, rApxII, rApxIII and rOMP can protect mice effectively against challenge with APP1 and APP2. This demonstrates that the recombinant subunit vaccine can induce favorable cross-protection. Compared with this, the cross-protection efficacy of the inactivated vaccine (Group III) was significantly lower than that in Group I. This may be due to the lower antibody level against Apx toxin in group III, which indicates the importance of Apx toxin for cross-protection [2,3,6]. The results showed that the antibodies against rApxI, rApxII, and rApxIII in Group I were higher than those in the other groups, which could have contributed to the better protection of this group. Furthermore, with increasing in the time since immunization, the antibody levels also increased, especially the antibodies against rApxI and rOMP; there was a large rise between the second and third immunization. Because ApxIV toxin has been shown to be produced only in vivo, it can not be extracted from cultures to design diagnostic tools from a culture of APP to use as the diagnostic antigen in iELISA. Therefore, we did not detect the antibody titer of rApxIV. However, the positive effect of rApxIV on the immune response is reflected in the results of the challenge experiment [30].
During these experiments, we showed that the protective efficacy of the vaccine did not improve against APP1 and APP2 after rApfa was added to the vaccine containing rApxI, rApxII, rApxIII and rOMP. Instead the protective efficacy was decreased, suggesting that the protective efficacy was lower than before. Suggesting that rApfa may just have a negative effect when combined with other factors in Group II, the antibody titers against rApxI, rApxII, rApxIII and rOMP decreased following the addition of rApfa. It is interesting that, the antibody titers against rApxI and rApxIII declined with an increase in the time since immunization. We propose that the rApfa may impair immunity or rApfa antibody counteracted the other antibodies to rApxI, rApxII, rAp-xIII and rOMP in Group II. However, we determined the antibody titer of rApfa, and the result showed that it rose slowly along with the increase in time since immunization. These results are similar to those of a previous study, in which the protective efficacy of a subunit vaccine containing three antigens (PalA, ApxI and ApxII) was considerably lower than that containing two antigens (ApxI and ApxII). This could indicate that PalA antibody counteracted ApxI and ApxII antibodies, and thus interfered with immunity [9].
In summary, rApfa interfere with the other antibodies against toxins of APP. Consequently, the fluorescence dots in group II were more dense and stronger than in group I and the mice in group II challenged with APP1 or APP2 had more severe lung lesions than those in group I. In addition, the survival rate of Group II was lower than that of Group I. It indicated that there was no positive correlation between the quantity of multicomponent recombinant vaccines antigen components and immune protection, the optimization of the antigen components was the key to a better immune protection.
Finally, which component of rApfa may interfere with immunity when mixed with other antigens should be studied further. After all, the mouse is only a model for this study.

Conclusion
The result of this study indicates that the multicomponent recombinant subunit vaccine composed of rApxI, rApxII, rApxIII and rOMP can provide effective crossprotection against challenge with APP1 and APP2.